Club Cars use an MCOR throttle device. This translates your foot movement at the pedal into electric impulse that the motor controller reads. MCOR stands for “Motor Controller Output Regulator”.
How do you test a club car MCOR?
To test the MCOR, look for the line item that says THROTLE. With the cart in neutral, slowly depress the gas pedal. You should verify that the throttle moves from 0% to 100% in a smooth manner. If you see it jump around (ie.
How much does an MCOR cost?
$42.99 & FREE Shipping.
How do I know what model my club car is?
The serial number on your Club Car can help you determine the model year. The serial number of each vehicle is printed on a bar code decal mounted either below the passenger side cup holder or above the accelerator or brake pedal (Example: PH0901-123456, as shown, or F9901123456).
Why does my club car jerk?
The most common reason for your golf cart jerking is often the battery terminal connections are loose and/or corroded. A poor connection prevents the correct amount of current from flowing through the set of batteries to your speed controller (or resistor coil), and ultimately to your electric motor.
What does a MCOR on a golf cart do?
Club Cars use an MCOR throttle device. This translates your foot movement at the pedal into electric impulse that the motor controller reads. MCOR stands for “Motor Controller Output Regulator”.
Where is the speed sensor located on a Club Car golf cart?
Typically, the speed sensor can be found on the backside of the motor. When removing the speed sensor, unplug all the cables that are on the backside of the motor. To do this, use a socket to take off the connector pigtail. Then, remove its plastic housing over the sensor.
How can I make my club car faster?
6 Ways You Can Make a Golf Cart Faster
Add More Torque to Your Golf Cart.Upgrade Your Golf Cart’s Motor.Improve the High-Speed Controller of the Cart.Add Better Golf Cart Tires.Use a Higher Powered Golf Cart Battery.Watch the Weight in Your Golf Cart.
What year is my Club Car by serial number?
The serial number of each vehicle is printed on a bar code decal. The two letters at the beginning of the serial number “A” indicate the vehicle model. The following four digits “B” indicate the model year and production week during which the vehicle was built.
What model is golf cart?
If you own an Yamaha Golf Cart you can determine the year and model by finding the serial number identification plate usually located under the glove box area on the driver side. Also can be found under the seat towards the floor of the cart or on the golf cart chassis under the rear bumper.
What would make a golf cart wobble?
Wobbly Golf Cart Whenever You Drive
Your cart may feel like it is going to fall apart and could experience some damage to its chassis as you ride. Poor tires are one of the most common causes of this problem. When your tires are not fully round, they are going to wobble a little and make your cart uneven.
What causes golf cart hesitation?
If your cart does not start smoothly, hesitates before starting, or does not gain speed properly, these are all signs of a bad or damaged accelerator.
Should you charge a golf cart after every use?
Yes. New golf cart batteries should be charged every time they are used as this will extend their lifespan, help them retain their capacity for longer, and prevent discharge. It is vitally important to charge new golf cart batteries, even after their first use.
